Tesla wins big as NHTSA drops three-year, 120k unit probe against Model Y

A probe into over 120,000 2023 Tesla Model Y units has been closed by the National Highway Traffic Safety Administration (NHTSA). The probe ends without the agency requiring any action from Tesla.

The probe, designated PE23-003, opened in March 2023 and stemmed from just two consumer complaints involving low-mileage Model Y SUVs.

In all, 120,089 Model Ys were impacted, but in two cases, drivers reported the complete detachment of the steering wheel from the steering column while the vehicle was in motion. NHTSA’s initial review revealed that the vehicles had been delivered without the critical retaining bolt that secures the steering wheel to the splined steering column.

NHTSA has ended a probe into over 120,000 Tesla Model Y vehicles after claims that the steering wheel could detach from the steering column due to a missing retaining bolt

There is no action needed by Tesla pic.twitter.com/YpAO3bKugA

— TESLARATI (@Teslarati) April 28, 2026

Factory records showed each car had undergone an “end-of-line” repair at Tesla’s facility, during which the steering wheel was removed and reinstalled. The bolt was apparently omitted after the repair, leaving only a friction fit between the wheel and column to hold it in place temporarily.

According to NHTSA documents, this friction fit maintained the connection during initial low-mileage driving until forces during normal operation caused the wheel to detach. Both vehicles that were impacted were repaired under warranty with no injuries reported, and no additional incidents surfaced during the agency’s three-year review.

Tesla Model Y steering wheel detachments prompt NHTSA probe

After analyzing manufacturing processes, complaint data, and field reports, NHTSA concluded the issue was isolated to those two post-repair vehicles rather than indicative of a systemic defect in Tesla’s production or quality control.

The closure means the agency has determined no recall or further enforcement is warranted for this specific missing-bolt condition.

This outcome marks the second NHTSA investigation into Tesla closed without action this month, as a recent probe into the company’s “Actually Smart Summon” feature was also resolved in April.

Tesla Full Self-Driving feature probe closed by NHTSA

The two resolutions provide some relief for Tesla amid the continuous and somewhat unfair regulatory scrutiny of its vehicles, including open inquiries into driver assistance systems.

Importantly, the closed probe does not involve or affect Tesla’s separate May 2023 voluntary recall of certain 2022-2023 Model Y vehicles. That recall addressed a different issue—steering-wheel fasteners that were installed but not torqued to specification—prompted by a service technician’s observation of a loose wheel during unrelated repairs.

Tesla identified a small number of related warranty claims and proactively addressed the matter without NHTSA mandate.

The Model Y remains one of the world’s best-selling vehicles, and Tesla continues to refine its lineup, including the recent “Juniper” refresh. While federal oversight of the electric vehicle pioneer remains intense, this decision underscores that isolated manufacturing anomalies do not always translate into broader safety defects requiring recalls.

The post Tesla wins big as NHTSA drops three-year, 120k unit probe against Model Y appeared first on TESLARATI.